filename: TFS117.doc version 2.0 21.03.2003 vi telefilter filter specification tfs 117 1/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the pr oduct(s) and/or information contained herein w i thout notice. no liability is assumed as a result of their use or application. no rights under any patent accompany the sale of any such produc t(s) measurement condition ambient temperature: 23 c input pow er level: 0 dbm terminating impedance: * input: 288 ? || -22.2 pf output: 258 ? || -22.6 pf ch aracteristics remark: the reference lev e l for the relativ e attenuation a rel of TFS117 is the minimum of the pass band attenuation a min . this v a lue is defined as the insertion loss a e . the centre frequency f c is the arithmetic mean v a lue of the upper and low e r frequencies at the 3 db filter attenuation lev e l relativ e to the insertion loss a e . the giv en v a lues for the relativ e attenuation a rel and the group delay ripple hav e to be reached at the frequencies giv en below , ev en if the centre frequency f c is shifted due to the temper ature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f c . d a t a ty p. v a lue tolerance / limit insertion loss a e 5,0 db max. 8 db (reference level) nominal frequency f n - 117,4 mhz centre frequency 117,4 mhz - pass band ripple w i thin f n 90 khz 0,5 db max. 1 db relativ e attenuation a rel f n ... f n 90 khz 0,5 db max. 1 db f n 90 khz ... f n 200 khz 0,5 db max. 3 db f n 1,8 mhz ... f n 6 mhz 30 db min. 20 db f n 6 mhz ... f n 30 mhz 42 db min. 35 db f n + 30 mhz ... f n + 200 mhz 52 db min. 20 db f n - 30 mhz ... f n - 115 mhz 52 db min. 20 db group delay at f n 800 ns max. 1 s group delay ripple f n 90 khz 100 ns max. 1 s temperature coefficient of frequency ( tc f ) *) - 18 ppm/k - operating temperature range - - 10 c ... + 85 c storage temperature range - - 40 c ... + 85 c input pow er lev e l : max. 10 dbm *) the terminating impedances depend on parasitics and q-v a lues of matching elem ents and the board used, and are to be understood as reference v a lues only . should there be additional ques tions do not hesitate to ask for an application note or contact ou r design team. **) ? f c (hz) = tc f (ppm/k) x (t - t o ) x f cat (mhz) generated: checked / approv ed: or information.
filename: TFS117.doc version 2.0 21.03.2003 vi telefilter filter specification tfs 117 2/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the pr oduct(s) and/or information contained herein w i thout notice. no liability is assumed as a result of their use or application. no rights under any patent accompany the sale of any such produc t(s) cons truc tion a nd pin c onne c t ion (all dimensions in mm) t fs 1 1 7 r1 2 1 2 3 4 6 5 7 8 9 10 1 output 2 ground 3 ground 4 ground 5 ground 6 input 7 ground 8 ground 9 ground 10 ground date code date code y ear + month n 2001 p 2002 r 2003 ... 50 ? ma tc hing ne tw ork : l2 o u tput 50 o h m c2 i npu t 50 o h m c1 l1 sa w 2,3,4, 5 , 7 1 6 8,9, 10 or information.
filename: TFS117.doc version 2.0 21.03.2003 vi telefilter filter specification tfs 117 3/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the pr oduct(s) and/or information contained herein w i thout notice. no liability is assumed as a result of their use or application. no rights under any patent accompany the sale of any such produc t(s) stability characteristics after the follow i ng tests the filter shall meet the w hole specification: 1. shock: 500g, 18 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or g respectively , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; packin g tape & reel: iec 286 ? 3, w i th exeption of value for n and minimum bending radius; tape ty pe ii, embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters peer reel: 2000 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm d o p o e f w p 1 e m b o sse d car r i er t ape co ver t ape g p 2 b o a o 0 , 1 d 1 13 , 4 tape (al l di mensi ons i n mm) w : 16,00 0,3 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,1 f : 7,50 0,1 g(min) : 0,60 p2 : 2,00 0,1 p1 : 12,00 0,1 d1(min) : 1,50 a o : 7,60 0,1 bo : 9,60 0,1 ct : 13,5 0,1 r eel (all d i men s io n s in mm) a : 330 w 1 : 16,4 +2/-0 w 2 (max ) : 22,4 n(min) : 60 c : 12,8 0,1 a c n w 1 w 2 the minimum bending radius is 45 mm. the m ounting surface of the filters faces the bottom side of the embossed carrier tape. marking of the filters can be read if the upper side of the carrier tape is regarded w i th the sprocket holes on the right. or information.
filename: TFS117.doc version 2.0 21.03.2003 vi telefilter filter specification tfs 117 4/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the pr oduct(s) and/or information contained herein w i thout notice. no liability is assumed as a result of their use or application. no rights under any patent accompany the sale of any such produc t(s) a i r re flow te mpe r a t ure c onditions 1st and 2nd air reflow profile name: pre-heating periods main-heat ing periods peak temperature t e mp eratu r e: 150 c - 170 c over 200 c 255 c 5 c t i m e : 60 sec. - 90 sec. 20 sec. - 25 sec. c h i p - m ount a i r re f l ow pr of i l e ti m e / s e c . t e mper at ur e / c 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 2 0 4 0 6 0 8 0 100 120 140 160 180 200 220 240 t able for temperature vs. time during the air reflow process t o lerance of temperatures: 5 c time / sec. temperature / c time / sec. temperature / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120 or information.
filename: TFS117.doc version 2.0 21.03.2003 vi telefilter filter specification tfs 117 5/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the pr oduct(s) and/or information contained herein w i thout notice. no liability is assumed as a result of their use or application. no rights under any patent accompany the sale of any such produc t(s) history version reason of changes name date f ilter sp ecificatio n 2.0 - terminating impedances amd ty pical values added steiner 21.03.2003 or information.
|
